Milex - Oak Forest, IL, 60452

System or Part	Check Weekly	Check Monthly	Check Every 2 Months	Special Note
Air Filter			X	Check the air filter every other month. Replace it when it's dirty or as part of a tune-up. It is easy to reach, right under the big metal "lid", in a carbureted engine; or in a rectangular box at the forward end of the air duct hose assembly.
Antifreeze	X			Check the antifreeze/coolant level weekly. Some cars have transparent reservoirs with level markings. Fill to level marking with 50/50 solution of antifreeze and water. Caution: Do not remove the pressure cap when engine is hot.
Battery				Use extreme caution when handling a battery since it can produce explosive gases. Do not smoke, create a spark or light a match near a battery and always wear protective glasses and gloves. Have it checked with every oil change. Cables should be attached securely and be free of corrosion. If battery has filler holes, add only clear odorless drinking water.
Belts		X		Inspect belts and hoses monthly. Replace worn, glazed or frayed belts. Tighten them when more than 1/2" of slack can be depressed between the pulleys. Vehicles with spring loaded belt tensioners require no adjustment. Replace bulging, rotten or brittle hoses and tighten clamps. If a hose looks bad, or feels too soft or too hard, it should be replaced.
Brake Fluid		X		Check brake fluid monthly. First, wipe dirt from the brake master cylinder reservoir lid. Pry off the retainer clip and remove the lid or unscrew plastic lid, depending on which type your vehicle has. If you need fluid, add the approved type and check for possible leaks throughout the system. Fill to mark on reservoir. Caution: Do Not Overfill.
Engine Oil & Oil Filter				Check oil every other fill up. Remove the dipstick, wipe it clean. insert it fully and remove it again. If it is low, add oil. To maintain peak performance, change oil every 3,000 miles or 3 months, whichever comes first. Replace oil filter with every oil change.
Exhaust				Look underneath for loose or broken exhaust clamps and supports. Check for holes in muffler or pipes. Replace rusted or damaged parts. Have emission checked at least once per year for compliance with local laws
Hoses		X		Inspect belts and hoses monthly. Replace worn, glazed or frayed belts. Tighten them when more than 1/2" of slack can be depressed between the pulleys. Vehicles with spring loaded belt tensioners require no adjustment. Replace bulging, rotten or brittle hoses and tighten clamps. If a hose looks bad, or feels too soft or too hard, it should be replaced.
Lights				Be sure all your lights are clean and working, including brake lights, turn signals and emergency flashers. Keep spare bulbs and fuses in your vehicle.
Power Steering Fluid		X		Check power steering fluid level once per month. Simply remove the reservoir dipstick. If the level is down, add fluid and inspect the pump and hoses for leaks.
Shock Absorbers				Look for signs of oil seepage on shock absorbers, test shock action by bouncing the car up and down. The car should stop bouncing when you step back. Worn or leaking shocks should be replaced. Always replace shock absorbers in pairs.
Tires		X		Keep tires inflated to recommended pressure (it helps to own your own gauge). Check for cuts, bulges and excessive tread wear. Uneven wear indicates tires are misaligned or out of balance. Keep a record of tire rotation. Rotate at the first 5,000 miles and every 7,500 miles thereafter.
Transmission Fluid		X		Check transmission fluid monthly with engine warm and running, and parking brake on. Shift to drive, then to park. Remove dipstick, wipe dry, insert it and remove it again. Add the approved type fluid, if needed. Caution: Do Not Overfill!
Washer Fluid				Keep windshield washer fluid reservoir full. When topping off, use some windshield washer fluid on a rag to clean off the wiper blades. In the winter months, pay attention to the freezing point of the washer fluid.
Wiper Blades				Inspect windshield wiper blades whenever you clean your windshield. Do not wait until rubber is worn or brittle to replace them. Wiper blades should be replaced at least once per year, and more often if smearing or chattering occurs.

Contributed By:

Maintenance Awareness Program
4600 East West Highway
Bethesda, MD 20814

In collaboration with: Car Care Council

[Top of Page]

Before You Buy that Used Car...

AutoCheck
Make sure you know all the facts before buying a preowned car. Protect yourself and your investment with an AutoCheck vehicle history report!

For the Do-It-Yourselfer

ALLDATA DIY
Individual Online Diagnostic and Repair Information for the Automotive Enthusiast.

More from ALLDATA -
Recall Notices & Technical Service Bulletins

Auto Accessories

AutoAccessory.com
Autoaccessory.com, your headquarters for top quality auto, truck and S.U.V. accessories. You can order with confidence from the AutoAccessory.com. All items come with a 30 day money-back guarantee and lifetime warranty against manufacturers defects.


	[Top of Page]

Local Auto Parts Stores

		Nearby NAPA Auto Parts stores, with distance from Milex:
		2.2 miles	Orland Auto Parts 15420 S 70th Ct Orland IL, 60462 (708) 535-8762
		2.6 miles	Genuine Parts Co 4715 W 135th St Crestwood IL, 60445 (708) 385-10952

		5.2 miles	Worth Auto Parts 6603 W 111th St Worth IL, 60482 (708) 448-8762

		6.7 miles	Genuine Parts Company 11030 S Western Chicago IL, 60643 (773) 779-2312

		7.4 miles	Square Deal Auto Parts 3106 W 95th St Evergreen Park IL, 60805 (708) 636-3311

		9.3 miles	Genuine Parts Co 1333 S Halsted Chicago Heights IL, 60411 (708) 754-6272

	[Top of Page]

		ACDelco Parts Retailers

		AUTOZONE 14225 S. CICERO CRESTWOOD IL, 60445 (708) 388-4918

		MOTIVE PARTS COMPANY 15348 S 70TH COURT ORLAND PARK IL, 60462 (708) 614-6660

		AUTOZONE 17540 S KEDZIE AVE HAZEL CREST IL, 60429 (708) 922-9150

[Top of Page]